L-36.com

Soft Shackles


Introduction

Known by some as "the soft shackle expert," my soft shackle designs have been featured on platforms like Animated Knots and many YouTube channels. In the articles below, I'll guide you from the basics to crafting these shackles.

While I co-invented the stronger version, I personally lean towards the popular "better soft shackle". For added strength, opting for thicker Amsteel does the trick. The articles offer straightforward, step-by-step instructions, addressing any potential challenges.

On my boat, I rely on the better soft shackle for overlapping jib sheets, utilizing line shackles for the main halyard and light air sheets. The y-sheet shackle comes in handy for high-wind spinnaker sheets. Towards the end of the articles, explore additional designs that, though no longer in my personal use, may pique your interest.

Soft Shackles Overview

picture of making a soft shackle
The is the basic introduction to soft shackles. It shows what they are and the basics of how to use them. The following articles show how to make them as well as some variations and extensions.

View Article


A Better Soft Shackle

picture of making a soft shackle
A soft shackle that is a hybrid of two types provides the best of both worlds, imho. It is easy and fast to use, secure, and just as strong. In this article, I show you how to make them step by step including a calculator so that you can make one of any size with line from 7/64 to 5/16. You might also enjoy the YouTube Video where I show how to make it.

View Article


Soft Shackle How-to

picture of making a soft shackle
A step by step tutorial with pictures and a calculator that allows you to make any size soft shackle out of lines from 7/64 to 5/16 and have them come out the size you want.

View Article


Diamond Knot

picture of making a soft shackle
Step by step instructions with pictures showing how to tie a diamond knot.

View Article


Diamond Knot Animation

picture of making a soft shackle
Animation of a diamond knot being tied.

View Article


High Strength Soft Shackle

picture of making a soft shackle
Recient work by Brion Toss, Evans Starzinger, and myself has led to the development of a high strength soft shackle that Evens has tested to 230% of line strength. The secret to this added strength in primarily an increase in the strength of the knot, the weak point in conventional soft shackles. I should point out that Evans testing shows conventional soft shackles, with diamond knots, test at 170% of line strength, considerable above the "higher than line strength" number I have been using. While these two statements are consistant, the more percise number is considerably higher and higher than the testing I had done at NE Rope.

View Article




How to tie a button knot

picture of making a soft shackle
Unlike the diamond knot typically used in soft shackles, this button knot has all four strands coming out the same side. this allows the tails to be buried inside the standing ends increasing the strength of the knot when used as a stopper.

View Article


Soft Halyard or Line Shackle

picture of making a soft shackle
Soft Halyard or Line Shackle is fast, strong, and ideal for attaching any 12 strand line to something such as the head of a sail. On my boat, I use this type of soft shackle more than any other type. I use it to attach my halyard to the main sail. I use it to attach sheets to my spinnaker for my light air sheets. I also use it on control lines for my inhauler and twings.

View Article


Spinnaker soft Y-Sheet

picture of making a soft shackle
My old friend the dual soft shackle version 1 has found a new use. It is common practice to use some kind of tail on an asymmetric spinnaker to keep the clew away from the rigging. One version is called a Y-Sheet. It connects to eye splices in the sheets and extends to some kind of connection to the clew either with a knot or a shackle. This article shows how to use a soft shackle type arrangement and not only avoid the strength loss that you would get with a knot, but basically doubles the strength of the line used for a penalty of a small increase in the length of the rope you need.

View Article


Stopper Loop Variations

picture of making a soft shackle
There are many ways to attach a diamond stopper loop. Here are a few variations. Any of these can be used with the line shackle or the soft Y-sheet above.

View Article


Soft Shackle Variations

picture of making a soft shackle
A couple of the standard soft shackle variations are shown. The best variation is not shown and it is my improved soft shackle shown in "A Better Soft Shackle" above. Be sure to check out that article.

View Article


Hybrid Soft Halyard Shackle

picture of making a soft shackle
Yet another way to make a soft halyard shackle out of Amsteel. This is one that I was using on my boat until I got my new mast. The advantage is that the hybrid knot gives approximately full line strength but only extends a couple of inches so that the short splice will not end up making the line that goes into the sheaves fatter. This prevents extra wear in thinner halyard sheaves.

View Article




Soft Line Shackle on a Block

picture of making a soft shackle
Integrating a soft shackle on the line and using a modified butterfly knot you can attach the line to a block with no hard shackles and still be able to remove the block for service.

View Article


Double Soft Shackle

picture of making a soft shackle
A Double Ended Soft Shackle that is secured to eye spliced jib sheets and can be very quickly be attached to the clew of a jib. A stopper loop is permanently attached to the clew ring to serve as the receptor for the shackle eye.

View Article


Integral Halyard Shackle

picture of making a soft shackle
A variation on a soft shackle that forms in integral soft shackle on a main halyard.

View Article


Soft Shackle Testing Part 1

picture of making a soft shackle
Part 1 of three articles on soft shackle testing. In this test I establish that soft shackles are stronger than the line they are made of. In Part 2 I show that they are not 25% stronger than the line they are made of and in Part 3 I show the results of testing done by Brion Toss at New England Ropes where we show they are in this same range, but we have actual numbers.

View Article


Soft Shackle Testing Part 2

picture of making a soft shackle
This test compares the diamond knot part of the soft shackle with a line that is 25% stronger (equivalent). The diamond knot fails, which is the known failure mode of the soft shackle. Thus, a soft shackle is not as strong as the line it is made of times 1.28. In Part 3 of Soft Shackle testing, my improved shackles are tested and the results basically confirm my results from part 1 and Part 2. The conclusion is that a soft shackle is stronger than the line it is made of, but that is about all you can say. 2.8 times stronger like the guy selling them on eBay claims.

View Article


Soft Shackle Testing Part 3

picture of making a soft shackle
In Part 3 of the series on Soft Shackle testing I talk about the samples I sent to Brion Toss for testing at New England Rope. We tested both the new improved "Better Soft Shackle" and the Double Soft Shackle. The conclusion is the same as my own testing. A soft shackle is stronger than the line it is made of and the double soft shackle is half that strong but can be made somewhat stronger by using the next size line up for the diamond stopper loop.

View Article





NOTICE: Some pages have affiliate links to Amazon. As an Amazon Associate, I earn from qualifying purchases. Please read website Cookie, Privacy, and Disclamers by clicking HERE. To contact me click HERE. For my YouTube page click HERE